Hole in Southwest jet: Why didn't anyone get sucked out of the airplane?

Answers to your questions about the news.
April 4 2011 6:26 PM

That Didn't Suck

The top of a Southwest Airlines passenger jet popped open at 36,000 feet, but no one was blown out through the hole. Why not?

A Southwest airplane. Click image to expand.
A Southwest airplane

A five-square-foot hole opened in the roof of a Southwest Airlines jet as it was cruising at 36,000 feet on Friday afternoon. Passengers reported hearing an explosive noise and feeling "air being sucked out" of the cabin, but the pilot was able to land the plane safely and there were no major injuries. Why wasn't anyone blown through the hole?

Seat belts and safe distance. As the Explainer described six years ago, the phenomenon of explosive decompression is very real: People and objects can indeed be forced out of an airliner at cruising altitude when a large hole opens in its fuselage. This results from the substantial pressure difference between the external atmosphere at high altitudes and the air inside a pressurized cabin: When the cabin is breached, air rushes outward all at once. While such an event can involve thousands of pounds of force, it's focused in the area immediately surrounding the hole. A passenger seated just a few rows from a five-square-foot hole could probably hold himself down without a seat belt. Anyone who was wearing his seat belt would be very unlikely to sail through the gap, regardless of location. (That is, assuming their seats remain bolted to the floor.) The few people who have slipped through holes not big enough to bring down a commercial aircraft—and there are a handful of famous examples—were located right next to the breach and weren't wearing a seat belt low and tight across the hips.

How risky might the latest incident have been for passengers? The pressure differential between the cabin and the outside was approximately 7.5 pounds per square inch, and the hole measured 720 square inches. That means the maximum force applied would have been around 5,400 pounds—more than enough to blow an unrestrained person out of the plane. But a passenger would only feel that much force if he were literally plugging the hole with his body.

Keep in mind that the hole was not right next to any passengers or beneath their legs. It was in the ceiling of the cabin, which would have been at least two to three feet away from the heads of anyone sitting inside. At that distance, the force of an explosive decompression would be greatly dissipated. Air-flow patterns are complicated, and it's impossible to quantify this effect for any given passenger. But as a simple way to visualize the effect of distance, we might imagine the force spreading itself out across the surface of an expanding hemisphere centered on the hole. Using the formula for spherical surface area, we see that at a distance of three feet, the 5,400 pounds of force would be spread across an area of 8,143 square inches. Four feet from the hole, it would cover 14,476 square inches, and so on. As the force gets more and more stretched out, the proportion of it that would be working to push a body out of the plane diminishes. On top of that, the air would be free to flow around the passengers in their seats, which would make its impact still weaker. Since the hole was in the ceiling of the plane, any decompressive force would have had to act against the full body weight of any passengers, lifting them up and out of their seats before it could eject them in a gust of air.

Here's an experiment that illustrates the principle: Plug your sink drain with a rubber stopper, fill the sink with water, and then slowly remove the stopper. You'll notice that the stopper is much harder to budge when it's close to the hole and perfectly aligned with it. But tilt the plug slightly, or pull it out a little bit, and the force becomes barely noticeable. That's more or less analogous to what happens when a hole opens in a Boeing 737 at cruising altitude.

A brief review of similar incidents shows how unlikely it is for a passenger to fly out through a hole. In 1973, a window shattered (PDF) on a National Airlines DC-10, and the passenger sitting directly next to it had left eight inches of slack in his seat belt. He was blown out of the plane, but the person next to him didn't go anywhere.

In 1988, an enormous hole—at least 10 times bigger than the one from Friday—opened up in the roof of an Aloha Airlines jet. (The plane involved in that incident was, like the one from Friday, a Boeing 737 with metal fatigue caused by thousands of take-offs and landings.) While passengers seated directly beneath the hole suffered some cuts, concussions, and broken bones, only one person fell to her death—a flight attendant who happened to be standing in the aisle directly beneath the hole.

In 1990, one of the cockpit windows blew out of a British Airways BAC-111. The pilot, who had loosened his belt, was pushed halfway out the window. He saved himself by grabbing the controls with his feet, and the flight attendants managed to hold him steady during the 20-minute emergency landing. The co-pilot didn't budge.

Got a question about today's news? Ask the Explainer.

Explainer thanks George Bibel of the University of North Dakota, a Boeing consultant and author of Beyond the Black Box: The Forensics of Airplane Crashes.

TODAY IN SLATE

Politics

Talking White

Black people’s disdain for “proper English” and academic achievement is a myth.

Hong Kong’s Protesters Are Ridiculously Polite. That’s What Scares Beijing So Much.

The One Fact About Ebola That Should Calm You: It Spreads Slowly

Operation Backbone

How White Boy Rick, a legendary Detroit cocaine dealer, helped the FBI uncover brazen police corruption.

A Jaw-Dropping Political Ad Aimed at Young Women, Apparently

The XX Factor
Oct. 1 2014 4:05 PM Today in GOP Outreach to Women: You Broads Like Wedding Dresses, Right?
Music

How Even an Old Hipster Can Age Gracefully

On their new albums, Leonard Cohen, Robert Plant, and Loudon Wainwright III show three ways.

How Tattoo Parlors Became the Barber Shops of Hipster Neighborhoods

This Gargantuan Wind Farm in Wyoming Would Be the Hoover Dam of the 21st Century

Moneybox
Oct. 1 2014 8:34 AM This Gargantuan Wind Farm in Wyoming Would Be the Hoover Dam of the 21st Century To undertake a massively ambitious energy project, you don’t need the government anymore.
  News & Politics
Politics
Oct. 1 2014 7:26 PM Talking White Black people’s disdain for “proper English” and academic achievement is a myth.
  Business
Buy a Small Business
Oct. 1 2014 11:48 PM Inking the Deal Why tattoo parlors are a great small-business bet.
  Life
Outward
Oct. 1 2014 6:02 PM Facebook Relaxes Its “Real Name” Policy; Drag Queens Celebrate
  Double X
The XX Factor
Oct. 1 2014 5:11 PM Celebrity Feminist Identification Has Reached Peak Meaninglessness
  Slate Plus
Behind the Scenes
Oct. 1 2014 3:24 PM Revelry (and Business) at Mohonk Photos and highlights from Slate’s annual retreat.
  Arts
Brow Beat
Oct. 1 2014 9:39 PM Tom Cruise Dies Over and Over Again in This Edge of Tomorrow Supercut
  Technology
Future Tense
Oct. 1 2014 6:59 PM EU’s Next Digital Commissioner Thinks Keeping Nude Celeb Photos in the Cloud Is “Stupid”
  Health & Science
Science
Oct. 1 2014 4:03 PM Does the Earth Really Have a “Hum”? Yes, but probably not the one you’re thinking.
  Sports
Sports Nut
Oct. 1 2014 5:19 PM Bunt-a-Palooza! How bad was the Kansas City Royals’ bunt-all-the-time strategy in the American League wild-card game?